沼气脱硫的运行维护应符合哪些规定？_公司新闻_新闻资讯-山东恒能环保能源设备有限公司

分类导航

产品展示

联系我们

山东恒能环保能源设备有限公司

联系电话：18678860671

服务热线：0531-69953988

联系地址：中国(山东)自由贸易试验区济南片区孙村街道经十东路33688号章锦综合保税区联东U谷科创中心5号楼 101

沼气脱硫的运行维护应符合哪些规定？

首页- 新闻资讯 > 公司新闻

2021-10-26

沼气脱硫是一种简单，，成本相对较低的脱硫方法，也是一种应用更为广泛的脱硫方法。通过干式法从沼气中除去硫化氢的设备的基本原理是O2将硫化氢（H2S）氧化为硫或硫氧??化物的方法，也可以称为干氧化法。填充物放置在内部，填充层包括活性炭，氧化铁等。如今，氧化铁更为常用。气体以低流速从一端的入口进入容器，穿过容器中的填料层，硫化氢（H2S）被氧化成硫或硫氧化合物，并保留在填料层中。净化后的气体从容器另一端的出气口排出。

Biogas desulfurization is not only a simple, efficient and relatively low-cost desulfurization method, but also a more widely used desulfurization method. The basic principle of the equipment for removing hydrogen sulfide from biogas by dry method is that O2 oxidizes hydrogen sulfide (H2S) into sulfur or sulfur oxygen?? The chemical method can also be called dry oxidation method. The filler is placed inside, and the filler layer includes activated carbon, iron oxide, etc. Nowadays, iron oxide is more commonly used. The gas enters the container from the inlet at one end at a low flow rate and passes through the packing layer in the container. Hydrogen sulfide (H2S) is oxidized into sulfur or sulfur oxide compounds and retained in the packing layer. The purified gas is discharged from the air outlet at the other end of the container.

沼气脱硫的运行和维护应符合下列要求：

The operation and maintenance of biogas desulfurization shall meet the following requirements:

1、脱水脱硫装置中的冷凝水应定期排放。当室外温度接近0°C时，应每天排放冷凝水，并在排放时防止沼气泄漏。

1. The condensate in the dehydration and desulfurization unit shall be discharged regularly. When the outdoor temperature is close to 0 ° C, the condensate shall be discharged every day and the biogas leakage shall be prevented during discharge.
沼气脱硫

2、生物脱硫开始并正常进行后，应定期检查脱硫前后的硫化氢浓度变化，并且硫化氢的去除率应符合后端工艺的要求。当发现脱硫效率大大降低时，应及时补充循环的营养液。塔中的填料应每6-12个月清洁一次。

2. After biological desulfurization is started and carried out normally, the change of hydrogen sulfide concentration before and after desulfurization shall be checked regularly, and the removal rate of hydrogen sulfide shall meet the requirements of back-end process. When the desulfurization efficiency is greatly reduced, the circulating nutrient solution shall be supplemented in time. The packing in the tower shall be cleaned every 6-12 months.

3、应当定期检查干燥脱硫塔前后的硫化氢浓度和沼气压力变化。当不满足设计要求时，应更换脱硫剂或进行脱硫再生。

3. The changes of hydrogen sulfide concentration and biogas pressure before and after drying the desulfurization tower shall be checked regularly. When the design requirements are not met, the desulfurizer shall be replaced or desulfurization regeneration shall be carried out.

4、干式脱硫塔的再生应满足以下要求：

4. The regeneration of dry desulfurization tower shall meet the following requirements:

1）在塔内使用脱硫剂进行再生时，应关闭沼气的进，出口阀门，并旁路支管和排放阀门管道应打开。

1) When desulfurizer is used for regeneration in the tower, the inlet and outlet valves of biogas shall be closed, and the bypass branch pipe and discharge valve pipeline shall be opened.

2）当使用在线脱硫器再生时，应根据沼气中的硫化氢含量确定空气混合量和空气流速，塔内温度应低于70℃，且塔内的氧含量脱硫塔出口沼气应小于1％;

2) When the on-line desulfurizer is used for regeneration, the air mixing amount and air flow rate shall be determined according to the hydrogen sulfide content in the biogas. The temperature in the tower shall be lower than 70 ℃, and the oxygen content in the tower shall be less than 1% of the biogas at the outlet of the desulfurization tower;

3）脱硫剂应在2?3次再生后及时更换。更换脱硫剂时，操作员应戴防毒面具，房间应通风。

3) The desulfurizer shall be within 2? Replace in time after 3 times of regeneration. When replacing desulfurizer, the operator shall wear gas mask and the room shall be ventilated.

4）沼气脱硫废脱硫器的处置应符合环境保护要求。

4) The disposal of biogas desulfurization waste desulfurizer shall meet the requirements of environmental protection.

以上就是生物脱硫http://www.hneee.net为大家介绍的内容，感谢您在百忙之中查看我公司的信息内容，如果您想要了解的更多，欢迎您来电进行咨询!

The above is biological desulfurization https://www.hneee.net Thank you for checking the information of our company in your busy schedule. If you want to know more, you are welcome to call for consultation!

上一条沼气提纯制天然气的重要性你了解吗？2021-10-26

下一条沼气脱硫系统中电器仪表维护事项2021-10-26